Part of the Case IH Repair Manuals.
Covers the Case IH Maxxum 110-140 EP, Maxxum 110-140 Multicontroller EP and Maxxum CVT 110-130 tractors. It is part number 47665857, published February 2014. It handles Power shuttle, Semi-Powershift and CVT transmissions, SCR exhaust treatment and the electronic draft control hitch.
Coverage runs from the engine and crankcase through the powered front axle, rear and front PTO, service and trailer brakes, remote control valves, steering and cab climate. For electrical work you get wiring harness schematic frames, a full hydraulic schematic and the instrument-cluster fault code tables.
The capacities table sits in the Introduction, so you can check transmission oil against the 62 l or 65.5 l spec in seconds. Chapters follow system order. EDC hitch calibration is under Electrical systems - Electronic modules, one hop from the contents page.
What's Inside This Manual
| System | Pages | Key Topics |
|---|---|---|
| Front Matter and Introduction | 1-34 | Cover and Part Number, Contents, Safety Rules, Torque, Basic Instructions, Conversion Factors, Lubricants and Coolants, Capacities |
| Engine | 35-320 | Engine and Crankcase, Air Cleaners, Fuel Tanks, Fuel Injection System, Turbocharger, Intake and Exhaust, Aftercooler, Engine Cooling, Fan and Drive, SCR Exhaust Treatment |
| Clutch | 321-328 | Slip Clutch or Flywheel Damper |
| Power Shuttle and Semi-Powershift Transmission | 329-723 | Power Shuttle Transmission, External Controls and Internal Components, Semi-Powershift Transmission, Lubrication |
| CVT Transmission, Creeper and Overdrive | 724-950 | Continuously Variable Transmission (CVT), CVT External Controls, CVT Lubrication System, CVT Internal Components, Creeper, Overdrive |
| Four-Wheel Drive (4WD) System | 951-1016 | 4WD Electro-Hydraulic Control, Drive Shaft |
| Front Axle System | 1017-1242 | Powered Front Axle, Front Bevel Gear Set and Differential, Final Drive Hub, Steering Knuckles and Shafts, Axle Suspension Control |
| Rear Axle System | 1243-1362 | Powered Rear Axle, Rear Bevel Gear Set and Differential, Planetary and Final Drives |
| Power Take-Off (PTO) | 1363-1494 | Rear Electro-Hydraulic Control, Two-Speed Rear PTO, Three-Speed Rear PTO, Front PTO Control, Front PTO |
| Brakes and Controls | 1495-1660 | Hydraulic Service Brakes, Parking Brake, Front Axle Brake, Trailer Brake Hydraulic Control, Trailer Brake Pneumatic Control |
| Hydraulic Systems | 1661-1912 | Hydraulic Schematic, Reservoir, Cooler and Filters, Fixed and Variable Displacement Pumps, Charge Pump, Low Pressure System, Remote Control Valves, Auxiliary Pump, Three-Point Hitch Valve and Cylinder, Front Hitch |
| Hitches and Drawbars | 1913-1926 | Rear Three-Point Hitch Linkage |
| Frames and Ballasting | 1927-1950 | Frame |
| Steering | 1951-2034 | Steering Control, Tie Rods, Hydraulic Control Components, Steering Pump, Cylinders |
| Wheels | 2035-2050 | Front Wheels, Rear Wheels |
| Cab Climate Control | 2051-2156 | Heating, Ventilation, Air Conditioning |
| Electrical System and Wiring Harnesses | 2157-2961 | Electrical System Overview, Harnesses and Connectors, Connector Index, Wiring Schematic Frames |
| Engine Electrical, Charging and Battery | 2962-3089 | Engine Control System, Alternator, Battery, Fuel Tank System, SCR Electrical System, Engine Cooling Sensors |
| Electronic Modules and Fault Codes | 3090-3683 | Electronic Modules, Instrument Cluster Diagnostics, Fault Code Index, Calibration Procedures, EDC Hitch Calibration |
| Transmission, PTO and Hitch Electronic Controls | 3684-3943 | Cab Transmission Controls, Transmission Control System, Speed, Pressure, Temperature and Position Sensors, Ground Speed Control, Rear PTO Control, Parking Brake Electrical, Remote Valve Electric Control, HVAC Controls, Steering Control, Three-Point Hitch Electronic Control, GPS |
| Lighting, Cab Harnesses and Instruments | 3944-4068 | External Lighting Switches and Relays, Cab Harnesses and Connectors, Warning Indicators, Alarms and Instruments |
| Platform, Cab, Bodywork and Decals | 4069-4137 | Cab, Engine Hood and Panels |
| Special Tool Index | 4138-4157 | Special Tools Listed by Section |
Quick Reference Specifications
| Specification | Value | Page |
|---|---|---|
| Part number | 47665857 | p. 1 |
| Fuel tank (110/120/130 / 115/125/140 EP) | 175 l (46.2 US gal) / 227 l (60.0 US gal) | p. 31 |
| Cooling system (110/120/130) | 21 l (5.5 US gal) | p. 31 |
| Engine oil incl. filter (110/120/130 / 115/125/140 EP) | 10 l (2.64 US gal) / 15 l (3.96 US gal) | p. 31 |
| Transmission / rear axle / hydraulics (16x16) | 62 l (16.4 US gal) | p. 31 |
| Transmission / rear axle / hydraulics (24x24) | 65.5 l (17.3 US gal) | p. 31 |
| 4WD front axle differential | 9 l (2.38 US gal) | p. 31 |
| DEF/AdBlue tank | 37 l (9.8 US gal) | p. 31 |
| Front PTO | 0.5 l (0.13 US gal) | p. 31 |
