Part of the New Holland Operator Manuals.
A draft control knob nobody remembers turning, rear wheels on the wrong track, a filter change overdue: this 246-page New Holland TS110 operator manual PDF (OEM ID 6045329100) is the factory owner's book for all four TS series tractors. Operation fills nearly half the book: the 12 x 12, 24 x 24 and 16 x 16 transmissions, range and shuttle shift, independent PTO, Electronic Draft Control, remote valves, three-point linkage, drawbars and ballasting. Your service schedule runs from daily checks to 1200-hour intervals, with a lubrication chart, warning light guidance, weight and hydraulic specifications, and first 50-hour service forms. Tighten hydraulic and transmission oil filters 3/4 of a turn, and bring disc to rim nuts to 240 Nm (177 lbf.ft.). Baling stalls fast over one missing number. Bookmarks and searchable text find it fast, and printed sheets can live on the bench, take oily thumbprints, and keep you in the field until the last load is home.
What's Inside This New Holland TS90, TS100, TS110, TS115 Operator Manual
| System | Pages | Key Topics |
|---|---|---|
| Introduction | 3-22 | To the Owner, Product Identification, Important Environmental Considerations, Safety Precautions, Safety Decals, International Symbols, Airborne Noise Emission |
| General Information | 23-36 | Protective Guards, Controls and Instruments, Transmission Controls |
| Operation | 37-81 | |
| Starting and Stopping the Engine | 82-85 | Thermostart, Key-Start Switch, Starting Motor, Hand Throttle, Block Coolant Heater |
| X 12 and 24 X 24 Transmission | 86-93 | Main Shift Lever, Range Lever, Shuttle Lever, Direct Drive Button, Underdrive Button, Dump Switch |
| X 16 Transmission | 94-102 | Main Gearshift Lever, Range Lever, Shuttle Lever, Powershift Buttons, Gear Display |
| Differential Lock and Four Wheel Drive | 103-104 | Differential Lock Switch, Four Wheel Drive Switch, Fast Raise Switch |
| Independent Power Take-Off | 105-110 | P.T.O. Shaft, P.T.O. Selector Knob, P.T.O. Range Selector Lever, P.T.O. Guard, P.T.O. Indicator Lamp |
| Top Link Sensing Hydraulics | 111-112 | System Selector, Lift Control Lever, Adjustable Stop, Hydraulic Lift Rocker |
| Electronic Draft Control Hydraulics | 113-120 | Lift Control Lever, Raise/Lower Switch, Position/Draft Sensitivity Knob, Drop Rate Control Knob, Height Limit Control Knob, Slip Limit Control Knob |
| Remote Control Valves | 121-126 | Joystick Control, Remote Control Valve Levers, Lock Collar, Flow Control Valve, Couplers, Detent Screw |
| Three-Point Linkage | 127-135 | Lift Rods, Lower Links, Top Link, Hydraulic Lift Rocker, Flexible Link Ends, Walterscheid Hitch |
| Drawbars and Towing Attachments | 136-144 | Swinging Drawbars, Safety Chain, Rear Tow Hitches, Automatic Pick-Up Hitch, Fixed Tow Pin |
| Front Wheel Track Adjustment | 145-149 | Standard Axle, Tobacco Axle, Track Control Rod, Steering Stops, Dynamic Front Fenders |
| Rear Wheel Track Adjustment | 150-154 | Manual Adjust Rear Wheels, Power Adjust Rear Wheels, Wheel Disc, Clamp Rails, Stops |
| Ballasting and Tyres | 155-166 | Liquid Ballast, Cast Iron Weights, Front Wheel Weights, Tyre Pressure, Radial Tyres, Cross Ply Tyres |
| Lubrication and Maintenance | 167-203 | Lubrication and Maintenance Chart, Maintenance Requirements - Controlled by Warning Lights, Maintenance Requirements - Every 10 Hours or Daily |
| Maintenance Requirements - Every 1200 Hours or Annually | 204-211 | Fuel Injectors, Transmission Oil, Four Wheel Drive Axle Oil, Cab Air Filters, Battery Electrolyte, Clutch Calibration |
| Maintenance Requirements - Every 1200 Hours or Two Years | 212-214 | Cooling System, Antifreeze, Chemical Inhibitor, Air Cleaner Inner Element |
| Maintenance Requirements - As Required | 215-222 | Lighting Equipment, Fuses and Relays, Automatic Pick-Up Hitch, Engine Idle Speed, Clutch Interlock Cable, Tractor Storage |
| Specifications | 223-234 | General Dimensions, Weight Specifications, Hydraulic System Specifications |
| First 50-Hour Service Forms | 235-238 | Engine Oil Filter, Fuel Filter, Hydraulic Filter, Transmission Filter, Brake Adjustment, P.T.O. Operation |
| Index | 239-246 |
Quick Reference Specifications
| Specification | Value | Page |
|---|---|---|
| All Models | ||
| Disc to rim nuts torque | 240 Nm (177 lbf.ft.) | p. 151 |
| Transmission oil filter tightening | 3/4 of a turn | p. 195 |
| Hydraulic oil filter tightening | 3/4 of a turn | p. 198 |
| Injector retaining bolts torque | 22 Nm (17 lbf. ft.) | p. 205 |
| Leak-off line banjo fitting bolts torque | 8 Nm (6 lbf. ft.) | p. 205 |
| Transmission/Rear Axle Oil Capacity (12x12) | 56.8 litres | p. 206 |
| Transmission/Rear Axle Oil Capacity (16x16) | 60.6 litres | p. 206 |
| Front Hub Oil Capacity (each) | 3.0 litres | p. 207 |
| Front Axle Oil Capacity | 6.2 litres | p. 207 |
| Disc to hub nuts torque (two wheel drive) | 133 Nm | p. 182 |
| TS90, TS100, TS110 | ||
| Engine Oil Capacity (TS90, TS100, TS110) | 11.4 litres | p. 192 |
| TS115 | ||
| Engine Oil Capacity (TS115) | 20.9 litres | p. 192 |
